辐射法制备高亲水性聚对苯二甲酸乙二醇酯微粉

郭丰, 邢哲, 万文, 吴国忠

PDF(1724 KB)
PDF(1724 KB)
塑料科技 ›› 2025, Vol. 53 ›› Issue (02) : 43-46. DOI: 10.15925/j.cnki.issn1005-3360.2025.02.008
理论与研究

辐射法制备高亲水性聚对苯二甲酸乙二醇酯微粉

作者信息 +

Preparation of Highly Hydrophilic Polyethylene Terephthalate Micropowder via Radiation Grafting Method

Author information +
History +

摘要

通过辐射诱导接枝方法在聚对苯二甲酸乙二醇酯(PET)微粉表面成功接枝亲水性单体丙烯酸(AA)和2-丙烯酰胺-2-甲基丙磺酸(AMPS),制备高亲水性的PET微粉。在氮气氛围下对PET微粉(粒径20 μm)和AA/AMPS混合之后的半干状固体进行γ辐照处理,吸收剂量为100 kGy。结果表明:改性后的PET微粉分散性及亲水性随接枝率的增加而增强。当AA/AMPS单体质量浓度为20%,AA、AMPS质量比为2∶1的情况下,接枝率可达15.2%,改性PET在水溶液中具有良好的分散稳定性,水接触角由125.4°下降至60.3°。采用傅里叶变换红外光谱仪(FTIR)、扫描电子显微镜(SEM)、热重分析(TG)等分析方法证实AA/AMPS被成功接枝到PET微粉表面。

Abstract

Hydrophilic monomers, acrylic acid (AA) and 2-acrylamido-2-methylpropanesulfonic acid (AMPS), were successfully grafted onto the surface of polyethylene terephthalate (PET) micropowder via a radiation-induced grafting method to produce highly hydrophilic PET micropowder. The semi-dry solid mixture of PET micropowder (particle size 20 μm) and AA/AMPS was subjected to γ-irradiation under a nitrogen atmosphere with an absorbed dose of 100 kGy. The results showed that the dispersibility and hydrophilicity of the modified PET micropowder increased with the grafting rate. When the mass fraction of AA/AMPS monomers was 20% and the mass ratio of AA to AMPS was 2∶1, the grafting rate reached 15.2%, the modified PET exhibited good dispersion stability in aqueous solution, and the water contact angle decreased from 125.4° to 60.3°. Fourier transform infrared spectroscopy (FTIR), scanning electron microscopy (SEM), and thermogravimetric analysis (TG) were used to confirm the successful grafting of AA/AMPS onto the surface of PET micropowder.

关键词

聚对苯二甲酸乙二醇酯 / 丙烯酸 / 2-丙烯酰胺-2-甲基丙磺酸 / 亲水性 / 共辐射接枝

Key words

Polyethylene terephthalate / Acrylic acid / 2-acrylamide-2-methylpropanesulfonic acid / Hydrophilic acid / Radiation grafting

中图分类号

TQ323.41

引用本文

导出引用
郭丰 , 邢哲 , 万文 , . 辐射法制备高亲水性聚对苯二甲酸乙二醇酯微粉. 塑料科技. 2025, 53(02): 43-46 https://doi.org/10.15925/j.cnki.issn1005-3360.2025.02.008
GUO Feng, XING Zhe, WAN Wen, et al. Preparation of Highly Hydrophilic Polyethylene Terephthalate Micropowder via Radiation Grafting Method[J]. Plastics Science and Technology. 2025, 53(02): 43-46 https://doi.org/10.15925/j.cnki.issn1005-3360.2025.02.008

参考文献

1
房梅华.废PET制粉末涂料用聚酯树脂[J].杭州化工,1996(3):25-29.
2
郑博凯,张辉,邵媛媛,等.超细粉末涂料的研究进展[J].涂料工业,2017,47(8):76-82.
3
KOJIMA T, ELLIOTT J A. Effect of silica nanoparticles on the bulk flow properties of fine cohesive powders[J]. Chemical Engineering Science, 2013, 101(14): 315-328.
4
何涛,顾宇昕,张捷,等.热固性粉末涂料用饱和聚酯树脂的发展趋势与研究进展[J].现代涂料与涂装,2014,17(12):20-23.
5
柳炽秋,蔡业茂.高质量聚乙烯粉末涂料的制造工艺[J].材料保护,1993(4):19-21, 3.
6
韩宇莹.聚氯乙烯防腐涂料的制备及性能研究[D].青岛:青岛科技大学,2022.
7
李志宝,侯继宗,宋欢欢,等.聚丙烯塑料表面涂料的研究[J].现代涂料与涂装,2023,26(12):1-3, 7.
8
宋红玮,许忠斌,郑素霞.微波辅助回收废聚酯制备粉末涂料用聚酯树脂[J].化工学报,2008(8):2141-2148.
9
李正仁.热塑性粉末涂料用树脂[J].现代涂料与涂装,2007(5):30-34.
10
TAIMUR S, HASSAN U I M, YASIN T, et al. Synthesis of modified sepiolite-g-polystyrene sulfonic acid nanohybrids by radiation induced graft polymerization[J]. Radiation Physics and Chemistry, 2018, 148: 19-24.
11
KISMET Y. Change of mechanical properties of powder recyclate reinforced polyolefin based on gamma radiation[J]. Polymers, 2017, 9(9): 384.
12
SADEGHI S, IKEL ANL L, GÜLER E, et al. Enhancing proton conductivity via sub-micron structures in proton conducting membranes originating from sulfonated PVDF powder by radiation-induced grafting[J]. Solid State Ionics, 2018, 314: 66-73.
13
郭建明.PET双向拉伸吹塑成型技术[J].塑料科技,2000(4):9-11.
14
吴锐.一种水性PET底涂涂料及其制备方法和应用:CN103409046A[P].2013-12-04.
15
ZHU X, LI F S, GUAN X H, et al. Uniform-saturation modification for hydrophilicity improvement of large-scale PET by plasma-electrified treatment[J]. European Polymer Journal, 2022, 181: 111683.
16
LEPOITTEVIN B, COSTA L, PARDOUE S, et al. Hydrophilic PET surfaces by aminolysis and glycopolymer brushes chemistry[J]. Journal of Polymer Science Part A: Polymer Chemistry, 2016, 54(17): 2689-2697.
17
BECH L, MEYLHEUC T, LEPOITTEVIN B, et al. Chemical surface modification of poly(ethylene terephthalate) fibers by aminolysis and grafting of carbohydrates[J]. Journal of Polymer Science Part A: Polymer Chemistry, 2007, 45(11): 2172-2183.
18
CHO Y J, HONG C, CHOI H. Microwave-assisted glycolysis for PET with highly hydrophilic surface[J]. Industrial & Engineering Chemistry Research, 2013, 52(6): 2309-2315.
19
张爱玲,宋喆,李三喜,等.磺酸基团对高吸水性聚合物耐盐性的影响[J].沈阳工业大学学报,2013,35(5):520-524.
20
雍定利.高防潮性和耐盐性高吸水性树脂的合成与性能研究[D].武汉:武汉工程大学,2018.
21
SALAMI T O, PLANK J. Synthesis, effectiveness, and working mechanism of humic acid-{sodium 2-acrylamido-2-methylpropane sulfonate-co-N,N-dimethyl acrylamide-co-acrylic acid} graft copolymer as high-temperature fluid loss additive in oil well cementing[J]. Journal of Applied Polymer Science, 2012, 126(4): 1449-1460.
22
WANG H L, XU L, HU J T, et al. Radiation-induced oxidation of ultra-high molecular weight polyethylene (UHMWPE) powder by gamma rays and electron beams: A clear dependence of dose rate[J]. Radiation Physics and Chemistry, 2015, 115: 88-96.
23
LIU J, CHENG H, FROST R L, et al. The mineral tooeleite Fe6(AsO3)4SO4(OH)4·4H2O—An infrared and Raman spectroscopic study-environmental implications for arsenic remediation[J]. Spectrochimica Acta Part A: Molecular and Biomolecular Spectroscopy, 2013, 103: 272-275.
24
DEFONSI LESTARD M E, TUTTOLOMONDO M E, ALTABEF A BEN. Vibrational spectroscopy and conformation of S-ethyl thioacetate: CH3COSCH2CH3 and comparison with —C(O)S— and —C(O)O— compounds[J]. Spectrochimica Acta Part A: Molecular and Biomolecular Spectroscopy, 2015, 135: 907-914.
25
韩晓燕,张政朴.γ-射线辐照接枝制备几种功能性高分子材料[J].高分子学报,2008(7):639-643.
26
ÇELIK Ü S, BOZKURT A. The synthesis and proton-conducting properties of the copolymers based on 1-vinyl-1,2,4-triazole and 2-acrylamido-2-methyl-1-propanesulfonic acid[J]. Solid State Ionics, 2010, 181(11): 525-530.
27
SUŁKOWSKI W, BOREK J, DANCH A, et al. Application of TG for valuation of selected aliphatic diamide stabilisation effect on low density polyethylene[J]. Journal of Thermal Analysis and Calorimetry, 2004, 77(1): 363-372.
28
李会,曾虹燕,邢哲,等.高亲水性聚四氟乙烯微粉的制备及其性能研究[J].高分子学报,2016(9):1247-1253.
29
裴永兵,任晓林,谢德龙,等.聚丙烯酸酯可再分散粉体重构乳液的稳定机理[J].化学工程通讯,2022,9:1245-1250.
30
PEI Y B, REN X L, XIE D L, et al. Stabilization mechanism of the reconstituted emulsion of polyacrylate redispersible powder[J]. Chemical Engineering Communications, 2015, 202(9): 1245-1250.

评论

PDF(1724 KB)

Accesses

Citation

Detail

段落导航
相关文章

/